Throttle Body Problem Erratic Revvs

loopydoo2002 · Post by **loopydoo2002** » Mon Oct 31, 2005 9:59 pm

Hi im sure loads of people have done this and like them i am very pissed off and wish that i would just be able to leave things alone.

I changed the air filter on my 1.4 16v today and decided to clean out the crap from the throttle body. Now its all shiny looking but when i started it up it revvs up and down constantly between 1600rpm and 2100rpm. Ive tried loads and nothing will make it settle. Please anyone who can tell me how to sort this help?

Sorry if the answer is already out there but ive searched for ages and am fed up looking so just need help now!!!

bstardchild · Post by **bstardchild** » Mon Oct 31, 2005 10:37 pm

loopydoo2002 wrote:Hi im sure loads of people have done this and like them i am very pissed off and wish that i would just be able to leave things alone.

I changed the air filter on my 1.4 16v today and decided to clean out the crap from the throttle body. Now its all shiny looking but when i started it up it revvs up and down constantly between 1600rpm and 2100rpm. Ive tried loads and nothing will make it settle. Please anyone who can tell me how to sort this help?

Sorry if the answer is already out there but ive searched for ages and am fed up looking so just need help now!!!

You didn't search that hard.....

http://www.tigerstyle.co.uk/poloforum/v ... hp?t=16876

About three posts below yours

Disconnect the battery

Leave it for half and hour

Reconnect

Leave the throttle alone for a few mins - should be OK then

R1CH · Post by **R1CH** » Mon Oct 31, 2005 10:42 pm

i had new TB fitted ages ago,anyway my battery run low and reset something recently,the revs were all over,i disscinnected the battery for 25min,re-connected it and took it for a ''spirited'' drive on the M62,the revs still were a bit iffy (didnt want to settle below 2k) but after a week it calmed itself down and runs sweet now,good luck .

Musicfreek2002 · Post by **Musicfreek2002** » Wed Nov 02, 2005 5:59 pm

Ive just taken mine to a garage for the same problem and they have told me that my temperature sensor has gone so the car is trying to warm the engine up all the time by keeping high revs

loopydoo2002 · Post by **loopydoo2002** » Thu Nov 03, 2005 5:22 pm

You didn't search that hard.....

http://www.tigerstyle.co.uk/poloforum/v ... hp?t=16876

About three posts below yours

Disconnect the battery

Leave it for half and hour

Reconnect

Leave the throttle alone for a few mins - should be OK then

Actually pal its not the same problem at all, mine was revving up and down not sitting high all the time. Ive sorted it now and funny enough it was just a coincidence that i cleaned the throttle body at the same time the vacume pipe on the servo decided to split. This messed up the engine by letting in air so ive changed it now Â£17.50.

Thanks for the help anyway

david burton · Post by **david burton** » Fri Nov 04, 2005 10:05 am

wherabouts is the vacuum pipe located?

weren't polos recalled for this problem at some point?

loopydoo2002 · Post by **loopydoo2002** » Fri Nov 04, 2005 12:17 pm

I didnt know they were recalled!!! Strange, well if you remove your air box then you can see your servo in the top left corner near your brake fluid reservoir! There is a black plastic pipe that is connected to the servo and it goes down underneath the air box and fixes to the inlet manifold.

Its lucky that i noticed it because it was trashed, both ends had cracked and were only resting on. If i hit a bumpy road maybe i could have got into some trouble.

Phatman · Post by **Phatman** » Fri Nov 04, 2005 7:27 pm

Hi, my 1.4 Polo is in the shop as I write with the same problem! They think the throttle body stepper motor has gone kaput but say they need to run a full diagnostic to confirm. I cleaned the throttle body myself before taking it in, which wasn't paticularly dirty and had the battery disconnected for about an hour and that had no effect at all. Personally I thought it might be the coolant temp sensor, the symptoms seem to suggest it...but I'll let you know what the verdict is tomorrow :-/

Just checked out throttle body prices at G&S and they're not cheap!

fingers crossed!!

Phatman · Post by **Phatman** » Tue Nov 08, 2005 5:42 pm

Got the car back yesterday, turned out the throttle body had to be stripped and the nylon cogs cleaned as they were dirty! They were stopping the plate from resting properly on idle. Now works purrrfect

BTW The body then had to be recalibrated to the ECU so it's not a DIY fix

Noddy · Post by **Noddy** » Wed Nov 09, 2005 12:11 am

I think my coolant temperature sensor is dead. The temp gauge on the dash hasn't moved in three days despite some harsh driving.

I'm going to follow the Haynes manual's method for testing whether the actual sensor is f****d or not but was wondering if anyone else has had this problem and if there was an easier fix than paying the Dealer Â£27 for a new sensor?

The engine seems to be fine despite the sensor not giving a reading but am I actually raping my engine by not fixing this until the weekend?

Phatman · Post by **Phatman** » Sat Nov 12, 2005 6:30 pm

I'd test the guage first. German & Swedish might be a little cheaper than the main stealership...?

JTLondon · Post by **JTLondon** » Mon Nov 21, 2005 10:46 pm

Got a different TB problem here.

I was getting the air box removed so I could put in new plugs and decided to open up the air box and check if the air filter was dusty. I noticed a lot of fluid (petrol it seems) above the throttle body on the air box. Is this a big problem or problem if any?

What is this symptons of and what do I do to fix this?

UK-POLOS.NET - THE VW Polo Forum

Throttle Body Problem Erratic Revvs

Throttle Body Problem Erratic Revvs

Re: Throttle Body Problem Erratic Revvs